thejoe Ford F-650 SD

Ford F-650 SD recalls

10 recall campaigns, model years 2015 to 2025. Each lists the fault, the risk, and the fix you are owed.

10Campaigns

2015–2025Years affected

0Do-not-drive

Check your own car in one step

Your VIN is on the dashboard by the windscreen. It is on your insurance card too. Put it into nhtsa.gov/recalls. You get the open recalls for your exact car. The repair is free. Most recalls never expire.

What keeps failing

System	Campaigns
Steering	3
Parking Brake	3
Fuel System, Diesel	1
Seat Belts	1
Service Brakes, Air	1
Structure	1
Power Train	1

Every campaign

The text below is quoted from NHTSA word for word.

Parking Brake

16V182000 · reported 31/03/2016

The fault: Ford Motor Company (Ford) is recalling certain model year 2015-2016 F-650 and F-750 trucks manufactured January 28, 2015, to November 30, 2015. The clip that connects the hand operated parking brake actuator cable to the intermediate parking brake cable may fail.
What it can cause: If the parking brake cable connector clip fails, the vehicle may unexpectedly roll, increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will replace the parking brake cable connector clip, free of charge. The recall began on May 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S15.

Steering:linkages:tie Rod Assembly

24V494000 · reported 28/06/2024

The fault: Ford Motor Company (Ford) is recalling certain 2025 F-Super Duty F-650 and F-750 vehicles. The front axle tie rod assemblies may contain ball studs that have been incorrectly heat-treated, which can cause them to break, and possibly result in tie rod failure.
What it can cause: Tie rod failure can cause a loss of vehicle steering control and increase the risk of a crash.
The fix: Dealers will inspect and replace the front axle tie rod assembly as necessary, free of charge. Owner notification letters were mailed August 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S42.

Steering:linkages:tie Rod Assembly

17V594000 · reported 25/09/2017

The fault: Ford Motor Company (Ford) is recalling certain 2015 F-650 and F-750 trucks, equipped with certain Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
What it can cause: If the tie rod loosens, it may disconnect from the steering knuckle, causing a loss of steering control at lower speeds and increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary, free of charge. The recall is expected to begin November 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S30.

Steering:column

15V789000 · reported 24/11/2015

The fault: Ford Motor Company (Ford) is recalling certain model year 2016 F-650 trucks manufactured July 29, 2015, to September 3, 2015. The affected vehicles may have been built with an incorrect Park-Reverse-Neutral-Drive-Manual (PRNDM) steering column, instead of Reverse-Neutral-Drive-Manual (RNDM) steering column. If the vehicle has the incorrect steering column, is parked on a hill, and the PRNDM placed in "P", park pawl may fracture due to being overloaded.
What it can cause: If the park pawl fractures, the vehicle may unexpectedly move, increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will replace the PRNDM steering column with the correct RNDM steering column, free of charge. The recall began on January 5, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S35.

Parking Brake

24V143000 · reported 23/02/2024

The fault: Ford Motor Company (Ford) is recalling certain 2023-2024 F-650 and F-750 vehicles. The parking brake may malfunction and allow the lever to be released without pressing the release button.
What it can cause: A parking brake that is released unexpectedly may result in a vehicle roll away, increasing the risk of a crash or injury.
The fix: Dealers will replace the parking brake handle assembly. Owner notification letters were mailed on June 17, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S09.

Service Brakes, Air:supply:hoses, Lines/piping, And Fittings

15V858000 · reported 22/12/2015

The fault: Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-650 and F-750 trucks manufactured April 15, 2015, to December 15, 2015, and equipped with rear air suspension. In the affected vehicles, the rear brake hoses may contact and chafe on the rear axle housing while driving.
What it can cause: A chafed rear brake line may result in an air leak, reducing the rear braking ability and increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will install revised rear brake air chambers and replace any damaged rear air brake lines, free of charge. The recall began on February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S38.

Seat Belts:front:anchorage

15V533000 · reported 20/08/2015

The fault: Ford Motor Company (Ford) is recalling certain model year 2011-2013 and 2015 Ford F-650, and F-750 trucks manufactured February 14, 2011, to April 28, 2015, and equipped with a 70% fixed bench passenger seat. The affected vehicles have passenger seat belt anchorage floor attachments that are not installed in the correct location. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
What it can cause: Seat belt anchors that are installed in an incorrect location may increase the risk of occupant injury in the event of a crash.
The fix: Ford will notify owners, and dealers will correct the seat belt anchorage locations, free of charge. The recall began on November 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C09.

Structure:frame And Members:underbody Shields

20V413000 · reported 17/07/2020

The fault: Ford Motor Company (Ford) is recalling certain 2021 F-650 and F-750 trucks equipped with 7.3L gasoline engines. The underbody heat shield and other heat-protection components were not installed during assembly. Without these components, the interior cabin floor and seat attachments may reach elevated temperatures in certain driving conditions.
What it can cause: Skin contact with certain areas of the cabin interior floor or seat attachments in these high temperature conditions may cause injury.
The fix: Ford will notify owners, and dealers will install the missing underbody heat shield, thermal insulator patch, seat base covers, and seat bolt covers, free of charge. The recall began September 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S36.

Power Train:automatic Transmission:internal:park Pawl

23V625000 · reported 08/09/2023

The fault: Ford Motor Company (Ford) is recalling certain 2024-2025 Ford E-350, F-650, and F-750 vehicles. The park pawl may not fully engage the park gear due to a casting defect in the transmission.
What it can cause: A vehicle which does not have the park pawl fully engaged may result in a vehicle rollaway, increasing the risk of a crash.
The fix: Dealers will inspect and replace the transmission, or the valve body and extension housing, as necessary, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford's customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S54.

Fuel System, Diesel

14V524000 · reported 02/09/2014

The fault: Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-650 SD trucks manufactured May 12, 2014, to July 22, 2014 and Ford F-750 SD trucks manufactured May 12, 2014, to August 4, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.
What it can cause: If the engine stalls unexpectedly there is an increased risk of a crash.
The fix: Cummins will notify the owners of the affected Ford vehicles, and Cummins service centers will replace the fuel filter with a non-defective one, free of charge. The recall began in September 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14V01. Owners may also contact Cummins customer service at 1-800-223-4583.

Source: NHTSA recalls API, retrieved 4 August 2026.

← All Ford models